Aerosol Bioburden and Antimicrobial Resistance in Orthopaedic Operating Unit in a Tertiary Hospital in Thailand

Kanokwan  Borwornphiphattanachai; Monchai  Ruangchainikom; Jiraluck  Nontarak; Yuwanda  Thongpanich; Fuangfa  Utrarachkij

doi:10.33192/smj.v77i3.269624

Authors

Kanokwan Borwornphiphattanachai Department of Nursing Siriraj Hospital, Faculty of Medicine Siriraj Hospital, Mahidol University, Bangkok 10700, Thailand; Department of Microbiology, Faculty of Public Health, Mahidol University, Bangkok 10400, Thailand
Monchai Ruangchainikom Department of Orthopaedics Surgery, Faculty of Medicine Siriraj Hospital, Mahidol University, Bangkok 10700, Thailand
Jiraluck Nontarak Department of Epidemiology, Faculty of Public Health, Mahidol University, Bangkok 10400, Thailand
Yuwanda Thongpanich Department of Microbiology, Faculty of Public Health, Mahidol University, Bangkok 10400, Thailand
Fuangfa Utrarachkij Department of Microbiology, Faculty of Public Health, Mahidol University, Bangkok 10400, Thailand

DOI:

https://doi.org/10.33192/smj.v77i3.269624

Keywords:

Aerosol S. aureus, Orthopaedic operating rooms, MRSA, Antimicrobial resistance

Abstract

Objective: This study aimed to determine the microbial indoor air quality and factors associated with bacterial air contamination in the orthopaedic operating unit.

Materials and Methods: Conducted in seven operating rooms (ORs) and six surrounding rooms (SRs) in an orthopaedic operating unit. A total of 352 air samples were collected using an Andersen air sampler. Fungal and bacterial counts were determined as air quality indicators. Antimicrobial resistance (AMR) of predominant bacteria and factors influencing microbial air quality were analyzed.

Results: Most air samples in the ORs (87.2%) and SRs (81.8%) contained acceptable fungal counts. However, unoccupied ORs (11.1%), occupied ORs (58.1%), and SRs (64.2%) had fewer samples with acceptable bacterial levels. The geometric mean (GM) bacterial load in the ORs before aerosol-generating procedures (AGPs) was 116.8±1.8 CFU/m³, higher than after AGPs (58.9±2.1 CFU/m³). After controlling potentially confounding factors, the factors influencing bacterial loads occupied OR were temperature before AGPs (0.164 CFU/m3, 95%CI 0.017-0.311, p=0.029), the number of staff after AGPs (0.082 CFU/m3, 95%CI 0.019-0.144, p=0.011), and using saw/drill device after AGPs (0.701 CFU/m3, 95%CI -1.326-0.076, p=0.029). Predominant bacteria were Gram-positive cocci (90.8%), of which 20.5% were S. aureus. Most S. aureus (94.2%) were resistant to at least one drug, with 40.7% being multidrug-resistant. Additionally, 33.7% were methicillin-resistant S. aureus (MRSA).

Conclusion: The indoor air of ORs and SRs may be a source of AMR bacteria, particularly MRSA, a concern for surgical site infections. Maintaining ventilation, cleanliness, and minimizing non-essential staff activities are crucial for reducing airborne pathogen transmission.

References

Ibrahim F, Samsudin EZ, Ishak AR, Sathasivam J. Hospital indoor air quality and its relationships with building design, building operation, and occupant-related factors: A minireview. Front Public Health. 2022;10:1067764.

Mousavi MS, Hadei M, Majlesi M, Hopke PK, Yarahmadi M, Emam B, et al. Investigating the effect of several factors on concentrations of bioaerosols in a well-ventilated hospital environment. Environ Monit Assess. 2019;191(7):407.3. Tran VV, Park D, Lee YC. Indoor air pollution, related human diseases, and recent trends in the control and improvement of indoor air quality. Int J Environ Res Public Health.2020;17(8):2927.

Badia JM, Casey AL, Petrosillo N, Hudson PM, Mitchell SA, Crosby C. Impact of surgical site infection on healthcare costs and patient outcomes: a systematic review in six European countries. J Hosp Infect. 2017;96(1):1-15.

World Health Organization. Global guidelines for the prevention of surgical site infection. Geneva, Switzerland: World Health Organization; 2019.

Chungsiriwattana W, Sangkhathat S, Kongkamol C, Suwalak N, Phainuphong P, Komet O, et al. Decreasing trend of surgical site infections among surgical patients in a university hospital in Thailand after an active surveillance program. Surg Infect (Larchmt). 2019;20(5):382-9.

Haque M, Sartelli M, McKimm J, Abu Bakar M. Healthcareassociated infections - an overview. Infect Drug Resist. 2018;11:2321-33.

Uçkay I, Hoffmeyer P, Lew D, Pittet D. Prevention of surgical site infections in orthopaedic surgery and bone trauma: state-of-the-art update. J Hosp Infect. 2013;84(1):5-12.

de Jong L, Klem TMAL, Kuijper TM, Roukema GR. Factors affecting the rate of surgical site infection in patients after hemiarthroplasty of the hip following a fracture of the neck of the femur. Bone Joint J. 2017;99-B(8):1088-94.

Bai Y, Zhang X, Tian Y, Tian D, Zhang B. Incidence of surgicalsite infection following open reduction and internal fixation of a distal femur fracture: An observational case-control study. Medicine (Baltimore). 2019;98(7):e14547.

Shillingford JN, Laratta JL, Reddy H, Ha A, Lehman RA Jr, Lenke LG, et al. Postoperative surgical site infection after spine surgery: An update from the scoliosis research society (SRS) morbidity and mortality database. Spine Deform. 2018;6(6):634-43.

Bhat AK, Parikh NK, Acharya A. Orthopaedic surgical site infections: A prospective cohort study. Canadian J Infect Control. 2018;33(4):227-9.

Godbole G, Wloch C, Harrington P, Verlander NQ, Hopkins S, Johnson AP, et al. Future priorities of acute hospitals for surgical site infection surveillance in England. J Hosp Infect. 2018;100(4):371-7.

Persson M. Airborne contamination and surgical site infection: Could a thirty-year-old idea help solve the problem? Med Hypotheses. 2019;132:109351.

Pasquarella C, Agodi A, Auxilia F, Lytsy B, Mura I, Parneix P, et al. Air quality in the operating theatre: a perspective. Aerobiologia. 2019;36(1):113-7.

Dai R, Liu S, Li Q, Wu H, Wu L, Ji C. A systematic review and meta-analysis of indoor bioaerosols in hospitals: The influence of heating, ventilation, and air conditioning. PLoS One. 2021;16(12):e0259996.

Montagna MT, Rutigliano S, Trerotoli P, Napoli C, Apollonio F, D’Amico A, et al. Evaluation of air contamination in orthopaedic operating theatres in hospitals in southern Italy: The IMPACT project. Int J Environ Res Public Health. 2019;16(19):3581.

Cristina ML, Sartini M, Schinca E, Ottria G, Spagnolo AM. Operating room environment and surgical site infections in arthroplasty procedures. J Prev Med Hyg. 2016;57(3):E142-8.

Fernstrom A, Goldblatt M. Aerobiology and its role in the transmission of infectious diseases. J Pathog. 2013;2013:493960.

Pasquarella C, Agodi A, Auxilia F, Lytsy B, Mura I, Parneix P, et al. Air quality in the operating theatre: a perspective. Aerobiologia. 2019;36(1):113-7.

Pasquarella C, Barchitta M, D’Alessandro D, Cristina ML, Mura I, Nobile M, et al. Collaborators. Heating, ventilation and air conditioning (HVAC) system, microbial air contamination and surgical site infection in hip and knee arthroplasties: the GISIO-SItI Ischia study. Ann Ig. 2018;30(5 Supple 2):22-35.

Pasquarella C, Balocco C, Colucci ME, Saccani E, Paroni S, Albertini L, et al. The influence of surgical staff behavior on air quality in a conventionally ventilated operating theatre during a simulated arthroplasty: A case study at the university hospital of Parma. Int J Environ Res Public Health. 2020;17(2):425.

Seo JH, Jeon HW, Choi JS, Sohn JR. Prediction model for airborne microorganisms using particle number concentration as surrogate markers in hospital environment. Int J Environ Res Public Health. 2020;17(19):7237.

Flouchi R, Elmniai A, El Far M, Touzani I, El Hachlafi N, Fikri-Benbrahim K. Microbiological monitoring of the environment using the “Association Rules” approach and disinfection procedure evaluation in a hospital center in Morocco. J Environ Public Health. 2021;2021:7682042.

Muthoni MS. Hospitals surfaces and sites as a reservoir for pathogenic bacteria that play a role in transmission of infectious diseases. J Health Environ Res 2021;7(3):139-44.

Sunagawa S, Koseki H, Noguchi C, Yonekura A, Matsumura U, Watanabe K, et al. Airborne particle dispersion around the feet of surgical staff while walking in and out of a bio-clean operating theatre. J Hosp Infect. 2020;106(2):318-24.

Birgand G, Toupet G, Rukly S, Antoniotti G, Deschamps MN, Lepelletier D, et al. Air contamination for predicting wound contamination in clean surgery: A large multicenter study. Am J Infect Control. 2015;43(5):516-21.

Luksamijarulkul P, Aiempradit N, Vatanasomboon P. Microbial contamination on used surgical masks among hospital personnel and microbial air quality in their working wards: A hospital in Bangkok. Oman Med J. 2014;29(5):346-50.

Matthew D, Dadah AJ, Mohammed SSD. Bacterial contamination of operating theatres: a case study of a hospital in Northern Nigeria. Science World J. 2020;15(2):83-9.

Wistrand C, Soderquist B, Sundqvist AS. Time-dependent bacterial air contamination of sterile fields in a controlled operating room environment: an experimental intervention study. J Hosp Infect. 2021;110:97-102.

World Health Organization. Patient safety: Making health care safer. Geneva, Switzerland: World Health Organization; 2017.

World Health Organization. Indoor air quality: biological contaminants. Copenhagen, Denmark: World Health Organization;1988.

Lindsley WG, Green BJ, Blachere FM, Martin SB, Law BF, Jensen PA, et al. Sampling and characterization of bioaerosols. In: Ashley K, O’Connor PF, editors. NIOSH manual of analytical methods (NMAM). 5th ed. Cincinnati: OH; 2014.p.BA1-115.

Montazeri A, Zandi H, Teymouri F, Soltanianzadeh Z, Jambarsang S, Mokhtari M. Microbiological analysis of bacterial and fungal bioaerosols from burn hospital of Yazd (Iran) in 2019. J Environ Health Sci Eng. 2020;18(2):1121-30.

Clinical and Laboratory Standards Institute. Performance standards for antimicrobial susceptibility testing; thirtieth informational supplement. M100-S30 Clinical and Laboratory Standards Institute, Wayne, PA; 2020.

Nasiri N, Gholipour S, Akbari H, Koolivand A, Abtahi H, Didehdar M, et al. Contamination of obstetrics and gynecology hospital air by bacterial and fungal aerosols associated with nosocomial infections. J Environ Health Sci Eng. 2021;19(1):663-70.

Fu SL, Chen IH, Chen CS, Wu HH, Lai LS, Chen YY, et al. Factors influencing microbial colonies in the air of operating rooms. BMC Infect Dis. 2018;18(1):4.

Núñez A & García AM. The aerobiome in a hospital environment: characterization, seasonal tendencies and the effect of window opening ventilation. Building and Environment. 2023;230:110024.

Yousefzadeh A, Maleki A, Athar SD, Darvishi E, Ahmadi M, Mohammadi E, et al. Evaluation of bio-aerosols type, density, and modeling of dispersion in inside and outside of different wards of educational hospital. Environ Sci Pollut Res Int. 2022;29(10):14143-57.

Asif A, Zeeshan M, Hashmi I, Zahid U, Bhatti MF. Microbial quality assessment of indoor air in a large hospital building during winter and spring seasons. Building and Environment. 2018;135:68-73.

Chaivisit P, Fontana A, Galindo S, Strub C, Choosong T, Kantachote D, et al. Airborne bacteria and fungi distribution characteristics in natural ventilation system of a university hospital in Thailand. Environment Asia. 2018;11(2):53-66.

Ogundare JO, Fakunle AG, Alege A, Elizabeth ST, Sylvia ME, Bolaji OM. Indoor airborne microbial burden of operating theatres in a tertiary hospital in South-Western Nigeria. Int J Curr Microbiol App Sci. 2017;6(9):3335 45.

Onmek N, Kongcharoen J, Singtong A, Penjumrus A, Junnoo S. Environmental factors and ventilation affect concentrations of microorganisms in hospital wards of Southern Thailand. J Environ Public Health. 2020;2020:7292198.

Yimer RM, Alemu MK. Bacterial contamination level of indoor air and surface of equipment in the operation room in Dil-Chora referral hospital, Dire Dawa, Eastern Ethiopia. Infect Drug Resist. 2022;15:5085-97.

Sadrizadeh S, Pantelic J, Sherman M, Clark J, Abouali O. Airborne particle dispersion to an operating room environment during sliding and hinged door opening. J Infect Public Health. 2018;11(5):631-5.

Sharma S, John R, Patel S, Neradi D, Kishore K, Dhillon MS. Bioaerosols in orthopedic surgical procedures and implications for clinical practice in the times of COVID-19: A systematic review and meta-analysis. J Clin Orthop Trauma. 2021;17:239-53.

Al-Moraissi EA, Kaur A, Günther F, Neff A, Christidis N. Can aerosols generating dental, oral and maxillofacial, and orthopedic surgical procedures lead to disease transmission? An implication on the current COVID-19 pandemic. Front Oral Health. 2022;3:974644.

Koseki H, Sunagawa S, Imai C, Yonekura A, Matsumura U, Yokoo S, et al. Visualization of airborne particles as a risk for microbial contamination in orthopedic surgery. Front Surg. 2021;8:754785. doi: 10.3389/fsurg.2021.754785.

Tolabi Z, Alimohammadi M, Hassanvand MS, Nabizadeh R, Soleimani H, Zarei A. The investigation of type and concentration of bio-aerosols in the air of surgical rooms: A case study in Shariati hospital, Karaj. MethodsX. 2019;6:641-50.

Parvizi J, Barnes S, Shohat N, Edmiston CE, Jr. Environment of care: Is it time to reassess microbial contamination of the operating room air as a risk factor for surgical site infection in total joint arthroplasty? Am J Infect Control. 2017;45(11):1267-72.

Chaoui L, Mhand R, Mellouki F, Rhallabi N. Contamination of the surfaces of a health care environment by multidrugresistant (MDR) bacteria. Int J Microbiol. 2019;2019:3236526.

Mengistu H, Mesfin W, Elshadie A. Intensive care units and operating rooms bacterial load and antibiotic susceptibility pattern. J Surg. 2016;4(2):60-4.

Jirawathin W, Siri S, Sujirarat D, Manomaipiboon, A. The environmental contaminate and drug-resistant nosocomial bacterial infection in hospital settings. Vajira Nursing J. 2021;25(1):58–69.

Pongbangli N, Oniem N, Chaiwarith R, Nantsupawat T, Phrommintikul A, Wongcharoen W. Prevalence of Staphylococcus aureus nasal carriage and surgical site infection rate among patients undergoing elective cardiac surgery. Int J Infect Dis. 2021;106:409-14.

Prestinaci F, Pezzotti P, Pantosti A. Antimicrobial resistance: a global multifaceted phenomenon. Pathog Glob Health. 2015;109(7):309-18.

Saenhom N, Kansan R, Chopjitt P, Boueroy P, Hatrongjit R, Kerdsin A. Evaluation of in-house cefoxitin screening broth to determine methicillin resistant staphylococci. Heliyon. 2022;8(2):e08950.

Murrell LJ, Hamilton EK, Johnson HB, Spencer M. Influence of a visible-light continuous environmental disinfection system on microbial contamination and surgical site infections in an orthopedic operating room. Am J Infect Control. 2019;47(7):804-10.

Alvarenga MOP, Dias JMM, Lima BJLA, Gomes ASL, Monteiro GQM. The implementation of portable air-cleaning technologies in healthcare settings - a scoping review. J Hosp Infect. 2023;132:93-103.